egr

Hi I have cleared code 401 3 times but , engine management light has come back on 3 times I suspect it is blocked egr cooler, I have took pics off freeze frame does anyone know what these readings are on freeze frame in pictures tia

Hi, My 204 kombi dsg is poorly sick. It broke down while on the motorway at about 75, heavy juddering and smoke from rear. Pulled over and really bad misfire. RAC diagnosed as turbo to get me home to the NW from Brighton. Garage diagnosed EGR valve, replaced and no better. They then swapped...

I'm about to put a deposit down on my most expensive vehicle yet - a 2016 4Motion 180 T32 T6... And I'm bricking it. I've been doing so much research around the forum and net but can't find a definitive answer on the 180 BiTurbo issue with the EGR. Lots of information on the problem, but only a...

Van spec: MY18 204tdi DSG, covered 43k. During the warranty period the EGR has been flushed 7 times, approximately every 6k miles. The last flush was done in January 2020. Each time the fault code was P0401 EGR insufficient flow. The warranty expired in February and the van is now showing the...

I had the egr replaced under warranty and it seems to be leaking coolant. It’s going in tomorrow to get looked at but I’m worried as the work was done 4 months ago and worried I’ll get told it’s not their problem. I have narrowed it down to where it’s leaking but am unsure how the fitment is...

Planning on buying a T6 2019 84kW/114PS, but reading the EGR-threads just gives me the chills. The thing about reading on forums is that the information can be rather one sided, people with problems are writing much more than those with no problems. Nothing wrong with that. (Everyone of course...

nicked from Facebook.

Has anyone had issues with T32 4motion 204bhp, bought one just out of warranty in the summer and all though it has full service history with vw and has had fly wheel ERG changed has been towed into Vw as has broke down making a terrible rattling sound , I have now been told that it will...

Hi guys, I've got a T6 102 which is showing an EGR fault on Carista but nothing on the dash. driving - under load at 60/70 when holding the throttle at a set point, after a minute or two the van will begin to lose power. Simply lifting off and back on the throttle clears the issue, as does...

Hi guys, my van is making a loud hissing noise from the engine when putting my foot down and there is a huge loss of power, I'm presuming it's a boost hose? that's come off or split? anything else i should be looking for? there is no engine light on. while the van is idling it won't rev above...

As far as the engine goes, I think an EGR delete would be worth it post extended warranty..

Hi all, New on this forum. I bought a t6 calif 2016 with 11000kms. On top of the engine seems to have a intercooler, what exactly is? How do you access glow plug ? Don't have to change right now but I'm learning my new toy ;-) Thx all, Regards.

Hi all, Firstly after looking at the info on here clearly you lot know your stuff so I am in safe hands! I am looking at buying a Ex-demo 2019 T6 2.0 TDI BMT 102 Highline Kombi Van Euro 6 with 15k on it from VW dealer directly for around 26k inc VAT, for a family van for day to day and to...

Workshop manual section with an overview of the EGR valve and cooler. This also includes the removal and fitting instructions.

A bit of a long shot, but has anyone had the foresight to buy an EGR Flexi pipe as a spare on the basis that they crack every 6 months :( I had that familiar smell in the cab yesterday and yup, another cracked EGR pipe, which will be my 4th. I will shoot over the TPS tomorrow morning, but I...

Workshop manual section for removal and refitting the flexible EGR pipes that are prone to cracking.

Is anyone able to point me in some direction. I have a 2016 SWB T32 Kombi 204PS BMT (65K miles) and it has been on the rolling road for a check up to find only 175BHP and 312 Ft/lb Torque, everything seems to be running smooth and no real hiccups pleanty of pull in the turbos to red line[ from...

Hello all My engine light has come on again on my T6 . It has again shown up as this fault - EGR- on diagnostic tool. Looks like I’ll have to purchase one or is there another fix that anyone knows of? If not are they easy Enough to fit cheers Glenn

Given the poorly engineered EGR cooler does anyone know of any specialist company that has taken on the task of supplying an improved version.... Huge potential for someone to make a living out of these...

Took my van in for a few jobs whilst still under warranty. Was told that there was an egr fault. They apparently followed a procedure and were expecting to have to flush it out but upon collection I was told it didn’t need the flush. Checked with carista and egr fault still present. Back to the...