bi-tdi

Hi...found an oil leak ...any ideas before head to garage..?? .cant see the source , oil has run down the front of oil sump...it a 2016 t6 euro 5 engine...never notice oil on the ground but it engine oil by the looks of it

Right guys, badly stuck, mechanics head is boggled. Van had recently got a head gasket replacement, and reconditioned injectors, bad diesel i think.. but now, van went great for few days after work, then apparently lost all power, black smoke, hasnt went right since. Hes checked turbo, egr, all...

Hi all Just stripped down and rebuilt the engine on a 2016 T6 180 bi-turbo CFCA engine after it failed on the A557 heading for Widnes originally had the van recovered to VW van center Liverpool for repair as I thought it was just a failed injector. After a couple of weeks, they said it had no...

Hi - brand noob to Transporters, looking for the right day van or something to make into one. A couple of people we've spoken to have said single turbo manuals are better because they're more reliable and more efficient. Is that true and to what extent, ie are biturbos a nightmare and dsg never...

I have noticed a few drips of oil on the floor where I normally park. Looked under neath to see a bit of a mess. It's oil I would say and quite clean oil at that. Took the under pan off to investigate and this is what I have found. I would normally take it straight to my local vw indy who do...

Hi I’ve got a T6 with the 204 BiTDI engine and upon opening the bonnet and looking at the oil cap I found a large amount of white/brownish foam on the cap and neck. I then started the engine and most of it blew out however some still remains. It is 2 and a half years old and has only done just...

Seen a van I like, and it’s advertised as bi turbo with 150bhp, is this right?, I though only the 180 and 204 were bi-turbo Next question, are they any good?

Hi I have seen a T6 65 plate bitdi Now my question is will this have the early engine being a 65 plate same as the 5.1 with all the problems? It’s done 100000 miles and is quite cheap,I thought t6 bitdi where 198 bhp, Any thoughts. This looking for a t6 is harder than buying a Cosworth lol

Evening all, Simple question you may think although I am struggling to find the genuine part number, can anyone shed some light please? Cheers all.

I'm about to put a deposit down on my most expensive vehicle yet - a 2016 4Motion 180 T32 T6... And I'm bricking it. I've been doing so much research around the forum and net but can't find a definitive answer on the 180 BiTurbo issue with the EGR. Lots of information on the problem, but only a...

Hi all, I've done a forum Search, but couldn't find what I was looking for. So my DSG on my 2017, 160k miles 204 PS Bi-Turbo is having 'issues'. Symptoms including not selecting gear at all, or 'dumping the clutch' in a *very* nasty way at a random point on the revs. Typically happens either...

Hi, sorry stupid question alert, does have an engine with an twin turbo equal 204 bhp, please , thankyou

I have a 2016 Bi turbo DSG and the lag on take off is bordering on dangerous. There is no Regen (whatever that is from previous thread) it hasnt been mapped - as far as i know. But pulling away nothing happens for the 1st few seconds till it gets to about 1000 rpm then all hell breaks loose :-)...

Hi, I have now done 10000 miles in my new van (180) I've now put in a total of 4 litres of oil!!! My dealer says it's normal to use 1 litre per 1000 miles!!! (Oil ain't cheap anymore!) Is this right? I also have a very annoying vibration that I think is coming from the small box compartment on...

LWB EU5 180 On the way to work the last couple of days I have noticed that in slow traffic at low revs there is a rumble and vibration at small throttle openings. In typical fashion I decided to warm it up and give it some red line beans, clean things out a bit. Now runs much better without...

Has anyone else had an oil warning light come on? Just had the oil warning light come on and done a check. The oil is right at the bottom of the stick. Anyone else used much? It's a 204ps with 6,000 miles.

Morning all, looking for advice please. Having read previous stories of the 180 bhp model suffering from increased oil consumption etc,etc ,is the latest 2019 T6 180 hp model ,still an issue ? or is all sorted. I've contacted VW commercial and the person I spoke to seemed uncertain , but...

Hi guys, So I've been looking at T6's and found a t6 which is on a 66 plate with 22k on the clock, after some digging (it's not on the advert) I've seen according to the finance on it its a BITDI 204ps TSPTR KV T32S 2 0 BITDI BM to be specific The spec is unreal, and the price is very keen...

Hi, I'm posting hoping to get some advice on Caravelles. It looks like we definitely want a DSG box, but other choices are up in the air. I've read that the biturbo engines get broken by EGR valve failures, is this the common feeling? I've also read that retrofitting options is difficult and...

hi all new member here dyslexic so if my spelling is rubbish please excuse. im looking at a 180 bhp but have been told by some people ( and one custom cenre) to avoid as they can have problems. Is this true or was it early ones etc. looking at a 2016