Search results for query: egr

  • Order by relevance
  1. A

    Rear EGR pipe part number

    Hi everyone, sorry there is a lot of posts regarding the EGR pipes around, too many to read all through. I have a cracked rear EGR pipe, bought a new one and after removing mine, found the part to be bigger. The part on my T6 is 04L431521H, however this doesnt show on google as being a part for...
  2. Salty Spuds

    204ps BiTurbo EGR cooler swap.

    Being the happy owner of the dreaded CXEB 204 PS, I’ve always had the nagging doubt in my head about the EGR cooler failure at around the 70k mile mark. Mine’s done 68k, so as a pre-emptive measure I asked VW for a price to swap the EGR/Cooler assembly. VW came back with coppers short of £2k. I...
  3. D

    EGR valve sensor

    Now then folks, I've just had my EGR valve changed and a minor service on my T6 T32 150 DSG. Drove it back from garage and all was good. Took it out today and I was getting a whistling sound when I accelerated. Got home and had a looks ie. Found a sensor completely dislodged in front of the...
  4. D

    P040200 EGR excessive flow – 2.0 TDI EA288 150hp 2018, cold start

    ...I have a VW Passat B8, 2018, 2.0 TDI, 150 hp (Euro 6). On cold start, once every 3–4 days, the EPC light comes on and the fault code P040200 (EGR excessive flow) is stored. The car goes into limp/safe mode. If I switch the engine off and start it again, the EPC light disappears and the car...
  5. Ryanpratt79

    EGR valve p0401

    Hi Looking for some advice, my engine management light came on, I’ve scanned it and came back with p0401 egr insufficient flow error code, I’ve only owned the van since march and looking at the paper work from the previous owner the EGR and cooler were replaced in sept 2024 the pipe was also...
  6. C

    Bi tdi t6 2017 coolant leak egr pipe

    Hi everyone im after some advice……I’ve had my van 6 months bought 2nd hand from vw leciester got 12 months warranty and apparently this isn’t covered as pipes are a wear and tear item? I would like to know if I blank off the EGR will this stop the coolant leaking from the egr pipe?
  7. L

    EGR cooler to valve gasket

    Just finished replacing my EGR. What a pig of a job. Hands are shredded! Was getting a slight loss of coolant, about half a litre every 500 miles or so. Took the old one apart and can see rust between the cooler and the valve. And could see corrosion on the gasket, so probably that’s where...
  8. L

    Losing coolant no leak - EGR damp

    ...(dashboard message) after 300 miles. Have mayo under oil filler cap and a bit of smoke/steam. Nothing on dipstick though. I took the front Egr pipe off and it wasn’t full of water like I’ve seen on others. But I stuck my finger in and it is definitely feeling ‘damp’ inside. So am...
  9. T

    EGR Rear Pipe Leak…

    ...I know this has been covered a few times on here but just after a bit of advice. Took my van in for a glow plug change and they noticed the Egr pipe between Egr and manifold (which I’m pretty sure is the rear) has split. They’ve quoted me £392.86 to change it, does this seem reasonable...
  10. T

    EGR and Adblue delete

    I had an egr delete done and approx 6 months later I began to have a range of adblue sensor faults and the dreaded countdown. I ended up deleting the DPF along with adblue. I am considering putting the dpf back in place without the egr for engine longevity and better running. I would have also...
  11. S

    Help with part egr cooler caravelle

    Hi Im trying to find an egr cooler for my 2016 caravelle, i believe engine code is cxfa but cant seem to find anywhere, preferably a pierburg one, does anyone know the correct part number please?
  12. Ryanpratt79

    Egr advice needed

    Hi guys Looking for some advice, we purchased our T6 in march prior to us getting it the egr valve,cooler and pipe where replace in November last year. The engine management light came on a couple of weeks ago and the codes relate to erg recirculation flow being insufficient the garage that...
  13. B

    Coolant issues - Heater matrix AND EGR cooler

    ...a small amount every month or so until recently). Garage have pressure tested the system and found no leaks, and have suggested a leak in the EGR cooler is the cause (It seems very similar to the issues on this thread: Coolant Leak [Resolved]). However, I also have an issue with the heater...
  14. D

    Losing coolant. EGR replaced last week.

    ...T6 T30 150 DSG. A week after we bought it the coolant light came on. We topped up and booked into a VAG specialist garage, who looked at the EGR with a endoscope which showed it had failed. We booked it in and had the EGR value and cooler replaced, the water pump and cam belt (as was due to...
  15. J

    EGR Valve advice

    ...it a once over as well, as we plan road trip to Italy next month. The van has gone straight through the MOT but the garage has said I need a new EGR valve at £1400. They’ve given a code readout in the attached image and 3 times on long journeys over the last year the engine light has come on...
  16. T

    High pitch noise after EGR change

    Hi all, Had my EGR changed last week due to the cooler leaking coolant. When I got my van back I noticed this high pitched noise when I press the accelerator which I’m sure wasn’t there before. Anyone had this before? Doesn’t happen all the time but mostly noticeable under load when driving...
  17. Bazza53

    EGR replacement cost.

    My 2017 T6 camper seems to require a replacement EGR valve. I've just been quoted £2300 to £2400 by an independent VW specialist! I'm a bit staggered by the amount but have very little info to base a decision as to whether this is a rip off or an acceptable amount to pay. I'm very reluctant to...
  18. T

    EGR cooler/valve life expectancy

    Hi. I’ve got a 67 plate Kombi, CXGB 102PS that’s had a history of EGR fault codes ‘insufficient flow’. It came to the end of an extended VW warranty in May and the dreaded amber warning light (exhaust fault) has just reappeared. I’m the second owner; I bought it at 3.5 years old with 77k on the...
  19. Paynewright

    EGR fault and front pipe sooting

    ...think anything of it as no dashboard fault light. Today I was under the bonnet with the engine running and got a whiff of fumes and noticed a sooty mark on the front egr stainless pipe. I’m wondering if the fault is because the pipe is leaking or the pipe is leaking because something is...
  20. D

    Coolanr Loss - EGR cooler & value replaced.

    Hello, We've been loosing coolant so last week had our EGR value & cooler replaced. We also had water pump and cam belt done at the same time so an expensive job. This was 6 days ago and were still loosing coolant. Checked coolant level this morning and a hiss came from the cap upon release. Any...
Back
Top